UK Offshore Oil and Gas Industry Safety Record Worse

Great Britain’s offshore oil and gas industry has been warned about its safety record as new statistics show increases in major injuries and unplanned hydrocarbon releases.

Figures released by the Health and Safety Executive (HSE) show there were 50 major injuries reported in 2009/10 − up 20 on 2008/09 and higher than the average of 42 over the previous five years. No workers were killed during activities regulated by HSE for the third year running.

The combined fatal and major injury rate almost doubled to 192 per 100,000 workers in 2009/10 compared with 106 in 2008/09 and 156 in 2007/08. (WCxKit)

A marked rise was also recorded in 2009/10 of the combined number of major and significant hydrocarbon releases, regarded as potential precursors to a major incident, with a provisional total of 85. There were 61 in 2008/09 − the lowest since HSE began regulating the industry.

In 2009/10 there was a significant reduction in the minor over-three-day injury rate, maintaining a downward trend – 414 workers per 100,000 reported an injury, compared with 496 in the previous year.

Statistics show 443 dangerous occurrences were reported, 34 fewer than in 2008/09. The main types reported were hydrocarbon releases (42%), failure of equipment offshore (23%) well-related incidents (6%) and failures relating to lifting operations (9%).

Steve Walker, head of HSE's offshore division noted, "I am pleased to see no fatalities for a third consecutive year in the areas we regulate, but the fact that 17 workers tragically died in other offshore related travel incidents in the year is a stark reminder that hazards are ever present offshore.

"Although the overall numbers of injury and dangerous occurrences are comparatively low, considering a workforce of almost 27,000 and the numbers of rigs and the continuous operations undertaken, this does not excuse the fact that the fatal and major injury rate has almost doubled. This year's overall health and safety picture is simply not good enough. The industry has shown it can do better and it must do in future. (WCxKit)

"We will continue to take a tough line on companies who put their workers at risk. The challenge to improve safety will be ever greater as more offshore installations exceed their original design life. Our new inspection initiative will check safety management plans to ensure ageing is being taken into account, but the responsibility for getting safety right in the first place rests where it always has – with the duty holders."